GORT

Reviews

Oil Leaking Our Of Weep Hole In Alpha 1 Lower Unit.

Di: Everly

I use 14- 15 psi to pressurize the entire drive (both upper and lower assembled) and NO gear oil in it. Should hold for about 1-2 minutes and your good to go. The Vacuum

If you observe oil leaking from a drain hole, it likely indicates a problem with the seals or gaskets. However, identifying the precise location of a leak can sometimes be difficult. Given that the

Oil leak from alpha 1 driveshaft

In the upper were the lower unit driveshaft stabs all the way up. the very upper seal is leaking. There is one below that as well but that’s the easy one to get to. The OEM service

Usually damaged when lower unit is separated while replacing the water pump impeller. stevieray Lieutenant Junior Grade. Joined Jul 18, 2006 Messages 1,135. Apr 18, 2007

Please see http://www.sterndrive.info/alpha-one/ for tech support and exploded view drawing.This video includes the following instructions:*A1 Installing up

Oil from that hole could come from the lower seals in the drive shaft housing, the shift shaft seal in the gear housing, the seals in the water pump base in the gear housing, or a

  • Mercruiser Alpha One: Q&A on Leaking Oil from Weep Hole
  • Mercruiser Alpha One gen2 leaking oil, but where?
  • Alpha one lower unit leaking oil out the side vent

To pressure test the lower unit once removed you would need to come up with a block off plate for the lube transfer tube that’s built into the outer wall. If I recall the weep holes allow the raw

Yamaha Lower Unit Leaking Oil from weep hole

Oil leak from alpha 1 driveshaft. Discussion in ‚Sterndrives‘ started by eman, Jun 2 , 2007. Joined: Jun 2007 Posts: 1 Likes: 0, Points: 0, Legacy Rep: 10 Location: Vancouver

Out in the garage with the boat now taking lower unit off. I got it separated but haven’t taken it all the way off but when I seperated it aboit .100 thou. Oil started coming out

Throughout the season, I noticed the lower unit oil reservoir would need topped off. We probably put 50 (or so) hours on it this season and went through maybe 1.5 quarts of

Hello, I recently had an oil leak in my Alpha one Gen 2. I replaced the shift shaft seal in the lower unit, but the issue ended up being the large gasket on the bell housing. I got

I have a 2002 Chapparral with 4.3 V6 and Alpha 1 outdrive. It is leaking a little gear oil where the lower unit bolts to the upper. I had to add a little oil to the reservoir. I checked the oil level

Allows oil to leak out of the drive into the waterpump area. 3. Quadseal where the oil runs between the upper/lower drive halfs – looks like an oval shaped grommet with fins on it.

  • Gear oil dripping from water s\\drain hole
  • Water in Alpha 1 stern drive lube oil need help on fix
  • oil dripping from weep hole alpha 1
  • Alpha One Lower Unit Leaking Oil? Find Solutions Here
  • Merc 3.0, Alpha One lower unit oil leak

Pressure testing the lower unit first at 10 PSI with my Mityvac after draining the oil and plugging the outlet where the oil goes through with the red seal, it held pressure, and I also

1. do you have to add gear oil over time (when using boat in season)? If your outdrive gear oil is staying full (at proper level) then you do not have a gear oil leak from

So I want to change my water pump in the alpha 1 . I noticed that over the winter theres oil leaking out of the starboard weep hole almost drained resivor completely . not water in oil . So I bought

You have a leak somewhere. 1. Shift shaft seal and/or 2. Oil carrier seal (cone shaped thing under water pump). No special tools for a Alpha I Gen II, not sure about an older Alpha. Probably a good idea to pressure test at this

I have a small gear oil leak coming out of my lower unit weep hole. The leak is coming out of the area where the shift The leak is coming out of the area where the shift Tan | 40 yrs. experience

Please Note. MarineEngine.com does not offer troubleshooting assistance or repair advice by email or by telephone. You are invited to join our public Boat Repair Forum to seek

The oil never made it to the upper vent hole, as it was leaking out of the weep hole on the starbord side, I suppose it could have drained into the inlet holes and I did not notice till

I took our „new“ cajun bassboat out yesterday and it ran like nearly new. The boat and motor haven’t been in the water for 10 years. I did all the expected maintenance – new fule

Im a machinist and a fairly good mechanic. I feel i can do this. I was give rhonda a call at lunch. Im not afraid of pulling the power head. Even though i have a nice shop i will still

If the upper or lower driveshaft seals, or the shift shaft seals, are leaking, that will show up as oil out of that weep hole. What any dealer would do is simply re-seal the entire drive unit. A re-seal runs about 1000 bucks.

General Boating Discussion – Water out of weep hole – Just wondering if I should be concerned or not, I have an alpha one gen 2 outdrive. Just did an impeller change as well

„On a Alpha 1 Gen 1 there is w „On a Alpha 1 Gen 1 there is what seems to be a weep hole on starboard side of lower unit above the water intake and a little forward. My

2000 yamaha 200 hpdi motor leaking engine oil out of the lower unit weep hole, checked under cowling did not see any oil leaks, checked and replaced lower unit oil, no water

After the gear oil stopped dripping out of the weep hole above the upper unit’s shift elbow, I noticed that hole is a vent for just beneath the gaskets around the oily top of the drive

In this video I take apart the outdrive lower and upper parts on an Alpha One to find the source of a gear oil leak. Gear oil was coming out of the water pum

„I have milky oil also, replac „I have milky oil also, replacing the water pump, base plate, shift shaft seal. The only difference with my issue is that the oil is leaking out the weep

Oil leaking from the weep hole in the front of the case is most likely a worn shift shaft seal. They are a common failed seal that I have seen. Also it could be the upper vertical

I’ve got an Alpha one Gen 2 and mine has a very small leak out the weep hole. It only will leak if I shift it into gear with the engine off sitting in the driveway. I found the shift shaft